Full HVAC System Replacement cost: Beaverton vs Eugene (2026)
In 2026, full HVAC system replacement is about 4% more expensive in Beaverton than in Eugene. Most homeowners pay around $12,600 in Beaverton versus $12,100 in Eugene — a gap of roughly $500.
Beaverton OR
Typically around $12,600
Eugene OR
Lower costTypically around $12,100
Beaverton vs Eugene: full breakdown
| Factor | Beaverton | Eugene |
|---|---|---|
| Typical 2026 cost | $12,600 | $12,100 |
| Estimated range | $8,850–$16,350 | $8,450–$15,700 |
| Labor index (vs US) | ×1.07 | ×1.03 |
| Climate zone | Mixed | Mixed |
| Climate factor | ×1 | ×1 |
| Local permit | $250 | $225 |
| Labor share | $7,550 | $7,250 |
| Materials/equipment | $5,050 | $4,850 |
Treat these as 2026 localized estimates for full HVAC system replacement, not quotes from a contractor.
How much should this gap actually matter?
4% is within noise for full HVAC system replacement — contractor selection and timing move the price more than which of these two metros you're in.
Full HVAC system replacement by type: Beaverton vs Eugene
Every full HVAC system replacement type gets its own localized price for each metro, using the same labor, climate and permit adjustments — a true apples-to-apples comparison.
| Type | Beaverton | Eugene |
|---|---|---|
| AC + gas furnace (split system) | $7,750–$14,200 | $7,450–$13,600 |
| Heat pump system (air-source) | $9,350–$17,400 | $9,000–$16,700 |
| Dual-fuel (hybrid heat pump + furnace) | $11,000–$19,550 | $10,550–$18,750 |
Localized 2026 planning estimates — not quotes. Each city adjusts the national full HVAC system replacement range for local labor, climate and permits.
Full HVAC system replacement by home size: Beaverton vs Eugene
A full system (furnace + AC, or a heat pump + air handler) is sized to the whole home. Replacing both together costs more upfront but shares labor, permits, and a single install visit.
| Size | Beaverton | Eugene |
|---|---|---|
| 1,000–1,500 sq ft | $7,750–$13,150 | $7,450–$12,600 |
| 1,500–2,000 sq ft | $8,850–$15,250 | $8,450–$14,650 |
| 2,000–2,500 sq ft | $10,450–$17,950 | $10,000–$17,200 |
| 2,500–3,000 sq ft | $12,050–$20,650 | $11,550–$19,800 |
| 3,000+ sq ft | $14,200–$23,850 | $13,600–$22,900 |
These are 2026 planning figures for full HVAC system replacement, localized to each city — not formal quotes.
What hvac pros earn in each metro
With labor making up about 60% of a full HVAC system replacement job, wage differences between metros do most of the work here. These figures are real BLS OEWS installer wages, not modeled estimates.
Portland-Vancouver-Hillsboro metro · about 12% above the US average installer wage.
No BLS metro wage series for Eugene; we use Oregon regional price parity instead.
Source: U.S. Bureau of Labor Statistics, OEWS metro wages for HVAC installers (used as a trade-labor index).
Cheapest time for full HVAC system replacement in either city
Demand for HVAC work falls off a cliff in the shoulder months, and contractors discount to keep their crews booked. Wait for a 100-degree day or a hard freeze, though, and you're paying emergency rates for a system that just quit.
How much should you really budget for HVAC in 2026?
Sizing, efficiency tier and brand pull a quote in different directions. Here's how our editors weigh the trade-offs that decide what you actually pay.
The longevity case
Brand is a footnote; sizing and install quality write the story. A right-sized mid-tier system that's properly commissioned and serviced once a year will outlive an oversized premium unit that short-cycles itself to an early grave. Put the money into the crew and the setup rather than the nameplate.
The efficiency-first case
Where you face brutal summers or hard winters, a higher SEER2/AFUE system or a heat pump runs enough hours to claw back its premium through lower bills — and utility or state rebates can still trim the sticker even though the federal 25C/25D credits closed at the end of 2025. Do the payback arithmetic before you reach for the cheapest box on the lot.
The budget-first case
Size the system to your home with a Manual J calculation and buy the standard efficiency tier (80% AFUE / 14.3 SEER2). In a mild climate the cheaper unit pays off because you rarely run it hard — paying for premium efficiency you won't use is the most common way to overspend.
Climate decides the efficiency tier; a proper load calculation decides everything else. Nail both, stack the rebates you can, and you've sidestepped the two mistakes — wrong size, rushed install — that actually inflate the lifetime cost.
Beaverton vs Eugene
Is full HVAC system replacement cheaper in Beaverton or Eugene?
Eugene comes out ahead here, at roughly $12,100 for full HVAC system replacement compared with $12,600 in Beaverton — a 4% ($500) gap as of 2026.
Why does full HVAC system replacement cost more in Beaverton than Eugene?
The main driver is local labor rates: Beaverton's labor index is 1.07 versus 1.03 in Eugene. Climate zone (mixed vs mixed) and permit fees also shift the total.
How much is full HVAC system replacement in Beaverton, OR?
Beaverton homeowners can expect $8,850 to $16,350 for full HVAC system replacement in 2026, with $12,600 the typical number.
When is the cheapest time to buy full HVAC system replacement — and does it differ by city?
The best window is the same in both Beaverton and Eugene: Spring and fall (Mar–May, Sep–Oct), when demand drops and installers discount to keep crews busy — typically 5–15% off peak pricing. The most expensive time anywhere is an emergency replacement during peak summer and mid-winter.
Should I choose where to live based on full HVAC system replacement cost?
Probably not. Yes, $500 is a real gap, but it's a one-time cost you can partly offset in Beaverton with off-season timing and tighter bids. Long-term factors like energy prices and home condition matter more than this one number.
Compare full HVAC system replacement in other cities
Updated June 2026 · By Serhat Özçelik